Notices
Project Cars / Build Threads Please post your build threads here.

2003 Evo 8: Restore or Replace?

Thread Tools
 
Search this Thread
 
Old Jan 10, 2021 | 02:02 PM
  #1  
redcat's Avatar
Thread Starter
Evolving Member
iTrader: (2)
 
Joined: Jan 2004
Posts: 201
Likes: 24
From: North Georgia
2003 Evo 8: Restore or Replace?

At a decision point with the Evo. Car has 133,000 miles, and I’ve owned it since new in December 2003. It is bone stock. Trying to decide if I should restore it, or sell it and go with a 2021 STI.

There are a few spots of rust on the car that concern me, see the attached photos. There is one on each rear wheel well, and one on the left side passenger door frame at the back of the door / front of the frame. I assume I can have someone cut all this rust out, and weld in fresh (I have found both used and new quarter panels online) material. Additionally I have a small rust spot on the trunk lid. After getting these fixed, I’d then have a few miscellaneous dents taken out and have the car completely re-sprayed Tarmac Black. I also need to re-clear the wing, and refresh the interior (buy new/used seats or dye the ones I have).

In the last three years, I have replaced the clutch, oil pan, both front wheel assemblies, gas tank and filler neck, and brake lines. Everything but the clutch was largely due to underbody rust after 17 years of winters in Connecticut (By the way, the Evo with snow tires is a beast in the snow). I’ll add that the timing belt, brakes, plugs and wires, and all other routine maintenance items are up to date.

What do you think? Worth investing in? Rough costs to restore with a very good re-spray? Love the car, and money is not too much of an option. I already have this Evo and a new Passat, plus three motorcycles, so I’m not looking to add a third car as I’ve got no garage space for a third, so it’s either restore or replace. Any guesses what repairing rust and re-spray would cost? Any recommendations for shops north of Atlanta, GA, should I choose to go this route?




Last edited by redcat; Mar 14, 2021 at 05:15 AM.
Reply
Old Jan 10, 2021 | 04:30 PM
  #2  
hutch959's Avatar
Evolved Member
iTrader: (18)
 
Joined: Nov 2004
Posts: 1,459
Likes: 110
From: Chattanooga, TN
is it just a weekend driver? play car? or a daily.

if it was a daily, i would sell it.

if it was my "project"... i would keep it and make it right
Reply
Old Jan 10, 2021 | 04:41 PM
  #3  
DontStopMe's Avatar
EvoM Guru
15 Year Member
Liked
Loved
Community Favorite
iTrader: (19)
 
Joined: Apr 2008
Posts: 750
Likes: 246
From: Wisconsin
Look at the rear frame rails - above the exhaust and the driver side. The rust underneath will be what determines if it worth saving.

Last edited by DontStopMe; Jan 10, 2021 at 04:55 PM.
Reply
Old Jan 10, 2021 | 04:53 PM
  #4  
redcat's Avatar
Thread Starter
Evolving Member
iTrader: (2)
 
Joined: Jan 2004
Posts: 201
Likes: 24
From: North Georgia
Daily. Thought about Project, but no place to store.

Will check rail, thanks!
Reply
Old Jan 11, 2021 | 10:53 AM
  #5  
Kevin.'s Avatar
EvoM Community Team Leader
15 Year Member
Photogenic
Liked
Community Favorite
iTrader: (7)
 
Joined: Oct 2009
Posts: 768
Likes: 148
From: PHL
Frame rail in front of the rear subframe mounting bolts are the two most concerning spots on the CT9A chassis. As said above the rear sidemember rails often go as well but are easier to fix. I've seen a lot of different EVOs rust and if your body is that bad I can't imagine what the chassis looks like. Mitsubishi release one of the best JDM cars in the USDM market and did nothing to protect the ungalvanized steel in crucial spots. You'll find undercoat in the middle of the chassis but nothing in the rear. Very poor manufacturing/quality control.

Best of luck
Reply
Old Jan 27, 2021 | 05:25 PM
  #6  
jarretpcurry's Avatar
Newbie
 
Joined: Jan 2021
Posts: 30
Likes: 9
From: Chicago, IL
I'd hold onto it and breathe some life back into it. I bought mine with a Rebuilt Title and plan on restoring it to it's former glory. Also, if you need a Daily I'd suggest the WRX over an STI. I had a '16 STI for a bit and am now dailyb driving a '20 WRX.
Reply
Old Jan 30, 2021 | 01:54 PM
  #7  
redcat's Avatar
Thread Starter
Evolving Member
iTrader: (2)
 
Joined: Jan 2004
Posts: 201
Likes: 24
From: North Georgia
I have an appointment next Saturday to bring the car to a restoration shop in my area. I've seen their work, and it is impressive. They do everything from basic mechanicals to full frame-off restorations.

Assuming there is not massive rust elsewhere once we get it on a lift (The rust in the pictures was just under the paint, and there is still much good metal there.), I'll write the shop a big $$$ deposit, and they will pull and paint all trim, repair rust, fix all dents, sand and reclear the wing, and respray the car. I will also talk to an upholstery shop about cleaning and dyeing the seats, or something more drastic to get them refreshed as well. I considered the STI (and also BMW's and Audi's, although getting these in a manual transmission is a real challenge), but for $40K for the higher-end STI's, I decided to reinvest in the Evo. I think if at a later date I do sell it, the work I am having done will increase the value of the car significantly.

If everything goes to plan, I will repost with photos in mid-March.
Reply
Old Jan 31, 2021 | 05:22 PM
  #8  
MuslimEvoFreak's Avatar
Evolved Member
20 Year Member
Photogenic
Photoriffic
Liked
iTrader: (39)
 
Joined: Dec 2004
Posts: 1,685
Likes: 13
From: Lake In The HIlls
Fix it.... I'm the original owner. I will be starting on the middle and rear possibly this year.
Reply
Old Feb 1, 2021 | 06:05 AM
  #9  
redcat's Avatar
Thread Starter
Evolving Member
iTrader: (2)
 
Joined: Jan 2004
Posts: 201
Likes: 24
From: North Georgia
Plan is to keep it. I've done so much on the mechanicals over the last 4 years (some of the routine stuff, and some not so routine, although the car is still completely stock), it would take a lot of bad news this coming Saturday to change the plan.

Very cool. You've got more talent than me. Probably not many of us original owners left. Good luck to you with the refresh, and keep us updated with pictures.

P.S. I also noticed your "Join Date". Probably not many have been hanging around here for 16-17 years either.

Last edited by redcat; Feb 2, 2021 at 10:56 AM.
Reply
Old Feb 19, 2021 | 09:48 AM
  #10  
redcat's Avatar
Thread Starter
Evolving Member
iTrader: (2)
 
Joined: Jan 2004
Posts: 201
Likes: 24
From: North Georgia
And so it begins . . .


Reply
Old Feb 19, 2021 | 10:22 AM
  #11  
ineedboostman's Avatar
Evolving Member
10 Year Member
Photogenic
Photoriffic
Shutterbug
iTrader: (2)
 
Joined: Dec 2011
Posts: 220
Likes: 8
From: Tri State
Glad to see it being restored. If this was a DSM someone would have parted it out and crushed it...
Reply
Old Feb 19, 2021 | 04:45 PM
  #12  
hutch959's Avatar
Evolved Member
iTrader: (18)
 
Joined: Nov 2004
Posts: 1,459
Likes: 110
From: Chattanooga, TN
nice!
Reply
Old Feb 19, 2021 | 05:07 PM
  #13  
ctfpevoVIII's Avatar
Evolved Member
iTrader: (4)
 
Joined: Feb 2012
Posts: 1,006
Likes: 66
From: connecticut
Glad your restoring it! Keep us posted.
Reply
Old Feb 19, 2021 | 07:20 PM
  #14  
Chrispy0530's Avatar
Evolving Member
15 Year Member
Photogenic
Liked
Loved
iTrader: (1)
 
Joined: Apr 2009
Posts: 307
Likes: 23
From: Miami, Florida
Following! Keep us updated
Reply
Old Feb 19, 2021 | 08:27 PM
  #15  
RallySport9's Avatar
Evolved Member
15 Year Member
Liked
Loved
Community Favorite
iTrader: (20)
 
Joined: Apr 2011
Posts: 1,429
Likes: 217
From: Canada
I think you made the right choice and i love that you're an original owner. Any newer subaru isn't going to be nearly as special as a viii ct9a or even worth as much as time goes on. These cars are aging very well and are about to become even bigger icons. Well worth the restoration and love to see you put it in good hands. Subbed. Very interested in seeing the results.
Reply



All times are GMT -7. The time now is 03:23 PM.